Biogas from Slaughterhouse Wastes

slaughterhouse-wasteSlaughterhouse waste (or abattoir waste) disposal has been a major environmental challenge in all parts of the world. The chemical properties of slaughterhouse wastes are similar to that of municipal sewage, however the former is highly concentrated wastewater with 45% soluble and 55% suspended organic composition. Blood has a very high COD of around 375,000 mg/L and is one of the major dissolved pollutants in slaughterhouse wastewater.

In most of the developing countries, there is no organized strategy for disposal of solid as well as liquid wastes generated in abattoirs. The solid slaughterhouse waste is collected and dumped in landfills or open areas while the liquid waste is sent to municipal sewerage system or water bodies, thus endangering public health as well as terrestrial and aquatic life. Wastewater from slaughterhouses is known to cause an increase in the BOD, COD, total solids, pH, temperature and turbidity, and may even cause deoxygenation of water bodies.

Anaerobic Digestion of Slaughterhouse Wastes

There are several methods for beneficial use of slaughterhouse wastes including biogas generation, fertilizer production and utilization as animal feed. Anaerobic digestion is one of the best options for slaughterhouse waste management which will lead to production of energy-rich biogas, reduction in GHGs emissions and effective pollution control in abattoirs. Anaerobic digestion can achieve a high degree of COD and BOD removal from slaughterhouse effluent at a significantly lower cost than comparable aerobic systems. The biogas potential of slaughterhouse waste is higher than animal manure, and reported to be in the range of 120-160 m3 biogas per ton of wastes. However the C:N ratio of slaughterhouse waste is quite low (4:1) which demands its co-digestion with high C:N substrates like animal manure, food waste, crop residues, poultry litter etc.

Slaughterhouse effluent has high COD, high BOD, and high moisture content which make it well-suited to anaerobic digestion process. Slaughterhouse wastewater also contains high concentrations of suspended organic solids including pieces of fat, grease, hair, feathers, manure, grit, and undigested feed which will contribute the slowly biodegradable of organic matter. Amongst anaerobic treatment processes, the up-flow anaerobic sludge blanket (UASB) process is widely used in developing countries for biogas production from abattoir wastes.

Slaughterhouse waste is a protein-rich substrate and may result in sulfide formation during anaerobic degradation. The increased concentration of sulfides in the digester can lead to higher concentrations of hydrogen sulfide in the biogas which may inhibit methanogens. In addition to sulfides, ammonia is also formed during the anaerobic digestion process which may increase the pH in the digester (>8.0) which can be growth limiting for some VFA-consuming methanogens.